Volkswagen Corrado (1993 year). Manual - part 201

 

  Index      Volkswagen     Volkswagen Corrado - service repair manual 1993 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  199  200  201  202   ..

 

 

Volkswagen Corrado (1993 year). Manual - part 201

 

 

TROUBLE SHOOTING - BASIC PROCEDURES 

                   Faulty ignition operation      Check wires for
                                                  cracks or poor con-
                                                  nections, test
                                                  secondary voltage
                                                  with oscilloscope

                   Contaminated fuel              Test fuel for water
                                                  or alcohol

                   Intermittent ECM ground        Test ECM ground
                                                  connection for
                                                  resistance

                   Restricted air cleaner         Replace air cleaner

                   Restricted exhaust system      Test for exhaust
                                                  manifold back
                                                  pressure

                   Poor MAF sensor signal         Check leakage
                                                  between sensor and
                                                  manifold

                   Poor VSS signal                If tester for ALCL
                                                  hook-up is available
                                                  check that VSS
                                                  reading matches
                                                  speedometer

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

Ping or Knock on   Poor Knock sensor signal       Test for shorted or
Acceleration                                      open sensor or
                                                  circuit

                   Poor Baro sensor signal        Test for shorted or
                                                  open sensor or
                                                  circuit

                   Improper ignition timing       See VEHICLE EMISSION
                                                  CONTROL LABEL (where
                                                  applicable)

                   Check for engine               Low coolant, loose
                   overheating problems           belts or electric
                                                  cooling fan
                                                  inoperative

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

NOTE:  For additional electronic fuel injection trouble shooting
       information, see the appropriate article in the ENGINE
       PERFORMANCE section (not all vehicles have Computer Engine

TROUBLE SHOOTING - BASIC PROCEDURES 

         GASOLINE ENGINE - MECHANICAL TROUBLE SHOOTING

WARNING: This is GENERAL information.  This article is not intended
         to be specific to any unique situation or individual vehicle
         configuration.  The purpose of this Trouble Shooting
         information is to provide a list of common causes to
         problem symptoms.  For model-specific Trouble Shooting,
         refer to SUBJECT, DIAGNOSTIC, or TESTING articles available
         in the section(s) you are accessing.

BASIC GASOLINE ENGINE  - MECHANICAL TROUBLE SHOOTING CHART

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

CONDITION         POSSIBLE CAUSE               CORRECTION

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

Engine Lopes At   Intake manifold-to-head      Replace manifold
Idle              leaks                        gasket, See ENGINES
                  Blown head gasket            Replace head gasket,
                                               See ENGINES
                  Worn timing gears, chain     Replace gears, chain or
                  or sprocket                  sprocket
                  Worn camshaft lobes          Replace camshaft, See
                                               ENGINES
                  Overheated engine            Check cooling system,
                                               See COOLING
                  Blocked crankcase vent       Remove restriction
                  valve
                  Leaking EGR valve            Repair leak and/or
                                               replace valve
                  Faulty fuel pump             Replace fuel pump

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

Engine Has Low    Leaking fuel pump            Repair leak and/or
Power                                          replace fuel pump
                  Excessive piston-to-bore     Install larger pistons,
                  clearance                    See ENGINES
                  Sticking valves or weak      Check valve train
                  valve springs                components, See ENGINES
                  Incorrect valve timing       Reset valve timing, See
                                               ENGINES
                  Worn camshaft lobes          Replace camshaft, See
                                               ENGINES
                  Blown head gasket            Replace camshaft, See
                                               ENGINES
                  Clutch slipping              Adjust pedal and/or
                                               replace components, See
                                               ENGINES
                  Engine overheating           Check cooling system,
                                               See COOLING
                  Auto. Trans. pressure

TROUBLE SHOOTING - BASIC PROCEDURES 

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

Faulty High       Low fuel pump volume         Replace fuel pump
Speed Operation
                  Leaking valves or worn       Replace valves and/or
                                               springs, See ENGINES
                  Incorrect valve timing       Reset valve timing,See
                                               ENGINES
                  Intake manifold restricted   Remove restriction
                  Worn distributor shaft       Replace distributor

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

Faulty            Improper fuel pump stroke    Remove pump and reset
Acceleration                                   pump stroke
                  Incorrect ignition timing    Reset ignition timing,
                                               See TUNE-UP
                  Leaking valves               Replace valves, See
                                               ENGINES
                  Worn fuel pump diaphragm     Replace diaphragm or
                  or piston                    piston

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

Intake Backfire   Improper ignition timing     Reset ignition timing,
                                               See TUNE-UP
                  Faulty accelerator pump      Replace accelerator
                  discharge                    pump
                  Improper choke operation     Check choke and adjust
                                               as required
                  Defective EGR valve          Replace EGR valve
                  Fuel mixture too lean        Reset air/fuel mixture,
                                               See TUNE-UP
                  Choke valve initial          Reset choke valve
                  clearance too large          initial clearance

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

Exhaust Backfire  Vacuum leak                  Inspect and repair
                                               vacuum system
                  Faulty vacuum diverter       Replace vacuum diverter
                  valve                        valve
                  Faulty choke operation       Check choke and adjust
                                               as required
                  Exhaust system leak          repair exhaust system
                                               leak

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

Engine            Ignition timing too far      Reset ignition timing,

TROUBLE SHOOTING - BASIC PROCEDURES 

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

External Oil      Fuel pump improperly seated  Remove pump, replace
Leakage           or worn gasket               gasket and seat
                                               properly
                  Oil pan gasket broken or     Straighten pan and
                  pan bent                     replace gasket
                  Timing chain cover gasket    Replace timing chain
                  broken                       cover gasket
                  Rear main oil seal worn      Replace rear main oil
                                               seal
                  Oil pan drain plug not       Remove and reinstall
                  seated properly              drain plug
                  Camshaft bearing drain       Remove restriction
                  hole blocked
                  Oil pressure sending         Remove and reinstall
                  switch leaking               sending switch

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

Excessive Oil     Worn valve stems or guides   Replace stems or
Consumption                                    guides, See ENGINES
                  Valve "O" ring seals         Replace "O" ring seals,
                  damaged                      See ENGINES
                  Plugged oil drain back holes Remove restrictions
                  Improper PCV valve           Replace PCV valve
                  operation
                  Engine oil level too high    Remove excess oil
                  Engine oil too thin          Replace thicker oil
                  Valve stem oil deflectors    Replace oil deflectors
                  damaged
                  Incorrect piston rings       Replace piston rings,
                                               See ENGINES
                  Piston ring gaps not         Reinstall piston rings,
                  staggered                    See ENGINES
                  Insufficient piston ring     Replace rings, See
                  tension                      ENGINES
                  Piston ring grooves or oil   Replace piston rings,

 

 

 

 

 

 

 

Content   ..  199  200  201  202   ..