Hyundai i30 (2018 year). Manual

At least monthly:

At least twice a year:

At least once a year:

(i.e., every Spring and Fall)

• Check coolant level in the engine

• Clean body and door drain holes.

coolant reservoir.

• Check radiator, heater and air condi-

• Lubricate door hinges and hood

• Check the operation of all exterior

tioning hoses for leaks or damage.

hinges.

lights, including the stoplights, turn

• Check windshield washer spray

• Lubricate door and hood locks and

signals and hazard warning flashers.

and wiper operation. Clean wiper

latches.

blades with clean cloth dampened

• Check the inflation pressures of all

• Lubricate door rubber weather

tires including the spare for tires

with washer fluid.

strips.

that are worn, show uneven wear,

• Check headlamp alignment.

• Check the air conditioning system.

or are damaged.

• Check muffler, exhaust pipes,

• Inspect and lubricate automatic

• Check for loose wheel lug nuts.

shields and clamps.

transaxle linkage and controls.

• Check the seat belts for wear and

• Clean the battery and terminals.

function.

• Check the brake fluid level.

7-9

Maintenance

SCHEDULED MAINTENANCE SERVICES

Follow Normal Maintenance Schedule if the vehicle is usually operated where none of the following conditions apply.

If any of the following conditions apply, you must follow the Maintenance Under Severe Usage Conditions.

• Repeated driving short distance of less than 8 km (5 miles) in normal temperature or less than 16 km (10 miles) in

freezing temperature

• Extensive engine idling or low speed driving for long distances

• Driving on rough, dusty, muddy, unpaved, graveled or salt-spread roads

• Driving in areas using salt or other corrosive materials or in very cold weather

• Driving in heavy traffic area

• Driving on uphill, downhill, or mountain road repeatedly

• Towing a trailer or using a camper, or roof rack

• Driving as a patrol car, taxi, other commercial use of vehicle towing

• Driving over 170 km/h (106 mile/h)

• Frequently driving in stop-and-go condition

If your vehicle is operated under the above conditions, you should inspect, replace or refill more frequently than the

following Normal Maintenance Schedule. After the periods or distance shown in the chart, continue to follow the pre-

scribed maintenance intervals.

7-10

Normal Maintenance Schedule (Gasoline Engine, for Europe)

MAINTENANCE

Months

120

144

168

192

INTERVALS

Miles x 1,000

100

120

140

160

MAINTENANCE

ITEM

Km x 1,000

120

150

180

210

240

At first, inspect at 90,000 km (60,000 miles) or 72 months,

Drive belts *1

after that, every 30,000 km (20,000 miles) or 24 months

1.0 T-GDI

Replace every 15,000 km (10,000 miles) or 12 months

Engine oil and

1.4 T-GDI

Replace every 15,000 km (10,000 miles) or 12 months

engine oil filter ** *2

MPI

Replace every 30,000 km (20,000 miles) or 12 months

Fuel additives *3

Add every 15,000 km (10,000 miles) or 12 months

Intercooler, in/out hose,

T-GDI

Inspect every 15,000 km (10,000 miles)

air intake hose

Air cleaner filter

T-GDI

Replace every 75,000 km (50,000 miles) *4 or 60 months

Spark plugs

MPI

Replace every 160,000 km (100,000 miles) *4 or 120 months

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

** : The engine oil level should be checked regularly and maintained properly. Operating with an insufficient amount of oil can dam-

age the engine, and such damage is not covered by warranty.

*1 : Inspect drive belt tensioner, idler and alternator pulley and if necessary correct or replace.

*2 : Check the engine oil level and leak every 500 km (350 miles) or before starting a long trip.

*3 : If good quality gasolines meet Europe Fuel standards (EN228) or equivalents including fuel additives is not available, one bot-

tle of additive is recommended. Additives are available from your authorized HYUNDAI dealer along with information on how to

use them. Do not mix other additives.

*4 : For your convenience, it can be replaced prior to it's interval when you do maintenance of other items.

7-11

Maintenance

Normal Maintenance Schedule (Gasoline Engine, for Europe) (Cont.)

MAINTENANCE

Months

120

144

168

192

INTERVALS

Miles x 1,000

100

120

140

160

MAINTENANCE

Km x 1,000

120

150

180

210

240

ITEM

Vapor hose and fuel filler cap

Fuel tank air filter

Fuel filter *5

Fuel lines, hoses and connections

Inspect “Coolant level adjustment and leak” every day.

Cooling system

At first, inspect 60,000 km (40,000 miles) or 48 months

after that, inspect every 30,000 km (20,000 miles) or 24 months

At first, replace at 210,000 km (120,000 miles) or 10 years :

Engine coolant *6

after that, replace every 30,000 km (20,000 miles) or 24 months *7

Battery condition

Brake lines, hoses and connections

Parking brake (if equipped)

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*5 : The fuel filter is considered to be maintenance free but periodic inspection is recommended for this maintenance schedule

depends on fuel quality. If there are some important matters like fuel flow restriction, surging, loss of power, hard starting prob-

lem etc, replace the fuel filter immediately regardless of maintenance schedule and consult an authorized HYUNDAI dealer for

details.

*6 : When adding coolant, use only deionized water or soft water for your vehicle and never mix hard water in the coolant filled at

the factory. An improper coolant mixture can result in serious malfunction or engine damage.

*7 : For your convenience, it can be replaced prior to it's interval when you do maintenance of other items.

7-12

Normal Maintenance Schedule (Gasoline Engine, for Europe) (Cont.)

MAINTENANCE

Months

120

144

168

192

INTERVALS

Miles x 1,000

100

120

140

160

MAINTENANCE

ITEM

Km x 1,000

120

150

180

210

240

Brake/clutch fluid

Disc brakes and pads

Steering gear rack, linkage and boots

Driveshaft and boots

Tire (pressure & tread wear)

Front suspension ball joints

Air conditioner refrigerant

Air conditioner compressor

Climate control air filter

Manual transmission fluid *8

Dual clutch transmission fluid *8

Automatic transaxle fluid

No check, No service required

Valve clearance (1.6 MPI) *9

Exhaust system

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*8 : Manual transmission/dual clutch transmission fluid should be changed anytime they have been submerged in water.

*9 : Inspect for excessive valve noise and/or engine vibration and adjust if necessary.We recommend that the system be checked

by an authorized HYUNDAI dealer.

7-13

Maintenance

Maintenance Under Severe Usage and Low Mileage Conditions (Gasoline Engine, for Europe)

The following items must be serviced more frequently on cars mainly used under severe and low mileage driving con-

ditions. Refer to the chart below for the appropriate maintenance intervals.

R : Replace I : Inspect and if necessary, adjust, correct, clean or replace

Maintenance

Maintenance item

Maintenance intervals

Driving condition

operation

Replace every 7,500 km (4,500 miles)

T-GDI

Engine oil and engine oil

or 6 months

A, B, C, D, E,

filter

Replace every 15,000 km (10,000 miles)

F, G, H, I, J, K

MPI

or 6 months

Replace more frequently

Air cleaner filter

C, E

depending on the condition

Replace more frequently

Spark plugs

B, H

depending on the condition

Inspect more frequently

Steering gear rack, linkage and boots

C, D, E, F, G

depending on the condition

Inspect more frequently

Front suspension ball joints

C, D, E, F, G

depending on the condition

Inspect more frequently

Disc brakes and pads, calipers and rotors

C, D, E, G, H

depending on the condition

Inspect more frequently

Parking brake (if equipped)

C, D, G, H

depending on the condition

Inspect more frequently

Driveshaft and boots

C, D, E, F, G, H, I

depending on the condition

7-14

Maintenance

Maintenance item

Maintenance intervals

Driving condition

operation

Replace more frequently

Climate control air filter

C, E, G

depending on the condition

C, D, E, F, G,

Manual transmission fluid

Every 120,000 km (80,000 miles)

H, I, J

A, C, D, E, F, G, H,

Automatic transmission fluid

Every 100,000 km (62,000 miles)

I, J

C, D, E, G, H,

Dual clutch transmission fluid

Every 120,000 km (80,000 miles)

I, J

Severe driving conditions

A :Repeatedly driving short distance of less than 5 miles (8 km)

E : Driving in the heavy dust condition

in normal temperature or less than 10 miles (16 km) in freez-

F : Driving in heavy traffic area

ing temperature

G:Driving on uphill, downhill, or mountain roads repeatedly

B :Extensive engine idling or low speed driving for long dis-

H :Towing a trailer, or using a camper or roof rack

tances

: Driving for patrol car, taxi, commercial car or vehicle towing

C :Driving on rough, dusty, muddy, unpaved, graveled or salt

spread roads

J :Driving over 170 km/h (106 mile/h)

K :Frequently driving in stop-and-go conditions and under

D :Driving in areas using salt or other corrosive materials or in

very cold weather

15,000 km per year.

7-15

Maintenance

Normal Maintenance Schedule (Gasoline Engine, except Europe)

MAINTENANCE

Months

INTERVALS

Miles x 1,000

MAINTENANCE

ITEM

Km x 1,000

105

120

Drive belts *1

MPI - Except Middle East,

Morocco, Egypt

Engine oil and

MPI - For Middle East,

engine oil filter *2 *3

Replace every 10,000 km (6,500 miles) or 12 months

Morocco, Egypt

T-GDI

Replace every 10,000 km (6,500 miles) or 12 months

Fuel additives *4

Add every 10,000 km (6,500 miles) or 12 months

Intercooler, in/out hose,

T-GDI

Inspect every 10,000 km (6,500 miles)

air intake hose

Except Middle East

Air cleaner filter

For Middle East

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*1 : Inspect drive belt tensioner, idler and alternator pulley and if necessary correct or replace.

*2 : Check the engine oil level and leak every 500 km (350 miles) or before starting a long trip.

*3 : The engine oil level should be checked regularly and maintained properly. Operating with an insufficient amount of oil can dam-

age the engine, and such damage is not covered by warranty.

*4 : If good quality gasolines meet Europe Fuel standards (EN228) or equivalents including fuel additives is not available, one bot-

tle of additive is recommended. Additives are available from your authorized HYUNDAI dealer along with information on how

to use them. Do not mix other additives.

7-16

Normal Maintenance Schedule (Gasoline Engine, except Europe) (Cont.)

MAINTENANCE

Months

INTERVALS

Miles x 1,000

MAINTENANCE

ITEM

Km x 1,000

105

120

T-GDI

Replace every 75,000 km (50,000 miles) *5 or 60 months

Spark plugs

MPI

Replace every 160,000 km (100,000 miles) *5 or 120 months

Vapor hose and fuel filler cap

Fuel tank air filter

Fuel filter *6

Fuel lines, hoses and connections

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*5 : For your convenience, it can be replaced prior to it's interval when you do maintenance of other items.

*6 : The fuel filter is considered to be maintenance free but periodic inspection is recommended for this maintenance schedule

depends on fuel quality. If there are some important matters like fuel flow restriction, surging, loss of power, hard starting prob-

lem etc, replace the fuel filter immediately regardless of maintenance schedule. We recommend that you consult an authorized

HYUNDAI dealer for details.

7-17

Maintenance

Normal Maintenance Schedule (Gasoline Engine, except Europe) (Cont.)

MAINTENANCE

Months

INTERVALS

Miles x 1,000

MAINTENANCE

ITEM

Km x 1,000

105

120

Inspect “Coolant level adjustment and leak” every day.

Cooling system

At first, inspect 60,000 km (40,000 miles) or 48 months

after that, inspect every 30,000 km (20,000 miles) or 24 months

At first, replace at 200,000 km (120,000 miles) or 120 months :

Engine coolant *7

after that, replace every 40,000 km (25,000 miles) or 24 months *5

Battery condition

Brake lines, hoses and connections

Parking brake (if equipped)

Brake/clutch fluid

Disc brakes and pads

Steering gear rack, linkage and boots

Driveshaft and boots

Tire (pressure & tread wear)

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*5 : For your convenience, it can be replaced prior to it's interval when you do maintenance of other items.

*7 : When adding coolant, use only deionized water or soft water for your vehicle and never mix hard water in the coolant filled at

the factory. An improper coolant mixture can result in serious malfunction or engine damage. For your convenience, it can be

replaced prior to it's interval when you do maintenance of other items.

7-18

Normal Maintenance Schedule (Gasoline Engine, except Europe) (Cont.)

MAINTENANCE

Months

INTERVALS

Miles x 1,000

MAINTENANCE

ITEM

Km x 1,000

105

120

Front suspension ball joints

Air conditioner refrigerant

Air conditioner compressor

Climate control air filter

Manual transmission fluid *8

Dual clutch transmission fluid *8

Automatic transmission fluid

No check, No service required

Valve clearance (1.6 MPI) *9

Exhaust system

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*8 : Manual transmission/Dual clutch transmission fluid should be changed anytime they have been submerged in water.

*9 : Inspect for excessive valve noise and/or engine vibration and adjust if necessary.We recommend that the system be checked

by an authorized HYUNDAI dealer.

7-19

Maintenance

Maintenance Under Severe Usage and Low Mileage Conditions (Gasoline Engine, except Europe)

The following items must be serviced more frequently on cars mainly used under severe driving conditions.

Refer to the chart below for the appropriate maintenance intervals.

R : Replace I : Inspect and if necessary, adjust, correct, clean or replace

Maintenance

Driving

Maintenance item

Maintenance intervals

operation

condition

MPI - Except Middle East,

7,500 km (4,500 miles) or 6 months

Morocco, Egypt

Engine oil and

MPI - For Middle East,

A, B, C, D, E, F, G,

5,000 km (3,000 miles) or 6 months

engine oil filter

Morocco, Egypt

H, I, J, K

T-GDI

5,000 km (3,000 miles) or 6 months

Replace more frequently

Air cleaner filter

C, E

depending on the condition

Replace more frequently

Spark plugs

B, H

depending on the condition

Inspect more frequently

Steering gear rack, linkage and boots

C, D, E, F, G

depending on the condition

Inspect more frequently

Front suspension ball joints

C, D, E, F, G

depending on the condition

7-20

Maintenance

Driving

Maintenance item

Maintenance intervals

operation

condition

Inspect more frequently

Disc brakes and pads, calipers and rotors

C, D, E, G, H

depending on the condition

Inspect more frequently

Parking brake (if equipped)

C, D, G, H

depending on the condition

Inspect more frequently

Driveshaft and boots

C, D, E, F, G, H, I, J

depending on the condition

Replace more frequently

Climate control air filter

C, E, G

depending on the condition

C, D, E, F, G,

Manual transmission fluid

Every 120,000 km (80,000 miles)

H, I, J

Automatic transmission fluid

Every 100,000 km (62,000 miles)

A, C, F, G, H, I, J

Dual clutch transmission fluid

Every 120,000 km (80,000 miles)

C, D, E, G, H, I, J

Severe driving conditions

A :Repeatedly driving short distance of less than 5 miles (8 km)

E : Driving in the heavy dust condition

in normal temperature or less than 10 miles (16 km) in freez-

F : Driving in heavy traffic area

ing temperature

G:Driving on uphill, downhill, or mountain roads repeatedly

B :Extensive engine idling or low speed driving for long distances

H :Towing a trailer, or using a camper or roof rack

C :Driving on rough, dusty, muddy, unpaved, graveled or salt

: Driving for patrol car, taxi, commercial car or vehicle towing

spread roads

J :Driving over 170 km/h (106 mile/h)

D :Driving in areas using salt or other corrosive materials or in

very cold weather

K :Frequently driving in stop-and-go conditions

7-21

Maintenance

Normal Maintenance Schedule (Diesel Engine, for Europe)

MAINTENANCE

Months

120

144

168

192

INTERVALS

Miles x 1,000

100

120

140

160

MAINTENANCE

Km x 1,000

120

150

180

210

240

ITEM

At first, inspect at 90,000 km (60,000 miles) or 48 months,

Drive belts *1

after that, every 30,000 km (20,000 miles) or 24 months

Engine oil and engine oil filter ** *2 *3 *4

Air cleaner filter

Fuel lines, hoses and connections

Fuel filter cartridge *5

Inspect “Coolant level adjustment and leak” every day.

Cooling system

At first, inspect 60,000 km (40,000 miles) or 48 months

after that, inspect every 30,000 km (20,000 miles) or 24 months

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

** : The engine oil level should be checked regularly and maintained properly. Operating with an insufficient amount of oil can dam-

age the engine, and such damage is not covered by warranty.

*1 : Inspect drive belt tensioner, idler and alternator pulley and if necessary correct or replace.

*2 : Check the engine oil level and leak every 500 km (350 miles) or before starting a long trip.

*3 : This maintenance schedule depends on fuel quality. It is applicable only when using a qualified fuel <"EN590 or equivalent">.

If the diesel fuel specifications don't meet the EN590, it must be replaced according to the severe maintenance schedule.

*4 : If the recommended oil is not available, replace engine oil and engine oil filter every 20,000 km or 12 months.

*5 : This maintenance schedule depends on fuel quality. It is applicable only when using a qualified fuel <"EN590 or equivalent">.

If the diesel fuel specifications don't meet the EN590, it must be replaced more frequently. If there are some important safety

matters like fuel flow restriction, surging, loss of power, hard starting problem etc., replace the fuel filter immediately regardless

of maintenance schedule. We recommend that you consult an authorized HYUNDAI dealer for details.

7-22

Normal Maintenance Schedule (Diesel Engine, for Europe) (Cont.)

MAINTENANCE

Months

120

144

168

192

INTERVALS

Miles x 1,000

100

120

140

160

MAINTENANCE

ITEM

Km x 1,000

120

150

180

210

240

At first, replace at 210,000 km (120,000 miles) or 10 years :

Engine coolant *6

after that, replace every 30,000 km (20,000 miles) or 24 months *7

Battery condition

Brake lines, hoses and connections

Parking brake (if equipped)

Brake/clutch fluid

Disc brakes and pads

Steering gear rack, linkage and boots

Driveshaft and boots

Tire (pressure & tread wear)

Front suspension ball joints

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*6 : When adding coolant, use only deionized water or soft water for your vehicle and never mix hard water in the coolant filled at

the factory. An improper coolant mixture can result in serious malfunction or engine damage.

*7 : For your convenience, it can be replaced prior to it's interval when you do maintenance of other items.

7-23

Maintenance

Normal Maintenance Schedule (Diesel Engine, for Europe) (Cont.)

MAINTENANCE

Months

120

144

168

192

INTERVALS

Miles x 1,000

100

120

140

160

MAINTENANCE

ITEM

Km x 1,000

120

150

180

210

240

Air conditioner refrigerant

Air conditioner compressor

Climate control air filter

Manual transmission fluid *8

Dual clutch transmission fluid *8

Exhaust system

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*8 : Manual transmission/dual clutch transmission fluid should be changed anytime they have been submerged in water.

7-24

Maintenance Under Severe Usage and Low Mileage Conditions (Diesel Engine, for Europe)

The following items must be serviced more frequently on cars mainly used under severe and low mileage driving con-

ditions. Refer to the chart below for the appropriate maintenance intervals.

R : Replace I : Inspect and if necessary, adjust, correct, clean or replace

Maintenance

Maintenance item

Maintenance intervals

Driving condition

operation

Replace every 15,000 km (10,000 miles)

A, B, C, D, E, F, G,

Engine oil and engine oil filter

or 12 months

H, I, J, K

Replace more frequently

Air cleaner filter

C, E

depending on the condition

Inspect more frequently

Steering gear rack, linkage and boots

C, D, E, F, G

depending on the condition

Inspect more frequently

Front suspension ball joints

C, D, E, F, G

depending on the condition

Inspect more frequently

Disc brakes and pads, calipers and rotors

C, D, E, G, H

depending on the condition

Inspect more frequently

Parking brake (if equipped)

C, D, G, H

depending on the condition

Inspect more frequently

Driveshaft and boots

C, D, E, F, G, H, I

depending on the condition

7-25

Hyundai i30 (2018 year). Manual - part 31