Volkswagen Corrado (1993 year). Manual - part 157

 

  Index      Volkswagen     Volkswagen Corrado - service repair manual 1993 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  155  156  157  158   ..

 

 

Volkswagen Corrado (1993 year). Manual - part 157

 

 

INTERFERENCE VERIFICATION CHECK FOR OHC ENGINE 

INTERFERENCE VERIFICATION CHECK FOR OHC ENGINE 

(1) - Other interference engine applications may exist which
      are not indicated here.
(2) - Interference engine. Check for possible damage to
      piston(s) or valve(s) if there has been a timing belt
      failure.
(3) - Although the vehicle manufacturer does not recommend a
      specific scheduled maintenance interval, aftermarket
      belt manufacturers suggest the belt be replaced at
      60,000 mile intervals.
(4) - Vehicle manufacturer recommends replacing all belts at
      the same time.

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

TIMING BELT INTERFERENCE VERIF. TABLE - LIGHT TRUCKS (1)

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

                                        Replacement Interval
Application              Engine                      (Miles)

Eurovan (Canadian)
  1992-96  ..........  2.5L 5-Cyl.  ............  (3) 60,000
Pickup
  1980  .......  (2) 1.5L 4-Cyl. Diesel  .......  (3) 60,000
  1980-83  ..........  1.6L 4-Cyl.  ............  (3) 60,000
  1981-83  ....  (2) 1.6L 4-Cyl. Diesel  .......  (3) 60,000
                       1.7L 4-Cyl.  ............  (3) 60,000
Transporter (Canadian)
  1992-96  ..........  2.5L 5-Cyl.  ............  (3) 60,000
Vanagon
  1981-82  ....  (2) 1.6L 4-Cyl. Diesel  .......  (3) 60,000

(1) - Other interference engine applications may exist which
      are not indicated here.
(2) - Interference engine. Check for possible damage to
      piston(s) or valve(s) if there has been a timing belt
      failure.
(3) - Although the vehicle manufacturer does not recommend a

INTERFERENCE VERIFICATION CHECK FOR OHC ENGINE 

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

END OF ARTICLE

J - PIN VOLTAGE CHARTS 

         1993 ENGINE PERFORMANCE
         Volkswagen Pin Voltage Charts

         Corrado SLC

         INTRODUCTION

         Pin voltage charts are supplied to reduce diagnostic time.
Checking pin voltages at ECU/ECM determines whether ECU/ECM is
receiving and transmitting proper voltage signals. Charts may also
help determine if ECU/ECM harness has an electrical short or open.

NOTE:    Unless stated otherwise in testing procedures, perform all
         voltage tests using a Digital Volt-Ohmmeter (DVOM) with a
         minimum 10-megohm input impedance. Voltage readings may vary
         slightly due to battery condition or charging rate.

         ECU PIN VOLTAGES (CORRADO SLC)

ECU PIN VOLTAGES (CORRADO SLC - MOTRONIC)

ÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄÄ

Component/Circuit           (1) Test Conditions &      Specified Value
(VAG 1598 Terminal No.)        Additional Steps         Or Test Result

ECU NOT CONNECTED TO VAG 1598/18
  Voltage Supply -
    Control Module (1 & 54)  ...  Ignition Off  .....  Battery Voltage
  Voltage Supply -
    Control Module
      Relay (1 & 23)  ........  (2) Ignition Off  ...  Battery Voltage
  Wiring To Fuel Pump
    (6 & 55 - Jumper)  .........  Ignition On  .......  Fuel Pump Must
                                                               Operate
  Heated Oxygen (O2)
    Sensor Relay (7 & 28 -
      Briefly Jumper)  .......  (2) Ignition On  .........  Relay Must
                                                       Operate (Click)
  Malfunction Indicator
    Light (5 & 10 - Jumper)  ...  Ignition On  ..  MIL Must Illuminate
  Wiring For A/C (39 & 55)  ....  Ignition On,
                                  A/C Switch On  ....  Battery Voltage
  Wiring To A/C Compressor
    (37 & 38 - Jumper)  ........  Ignition On  .........  A/C Magnetic
                                                       Clutch Operates
  Fuel Injector No. 1
    (23 & 24)  .................  Ignition Off  ........  15-21.5 Ohms
  Fuel Injector No. 2
    (3 & 23)  ..................  Ignition Off  ........  15-21.5 Ohms
  Fuel Injector No. 3

 

 

 

 

 

 

 

Content   ..  155  156  157  158   ..