Mercedes-Benz ML320. Service manual - part 96

 

  Index      Mercedes     Mercedes-Benz ML320 - service and repair manual 1997-2005 year

 

Search            copyright infringement  

 

 

 

 

 

 

 



 

 

Content   ..  94  95  96  97   ..

 

 

Mercedes-Benz ML320. Service manual - part 96

 

 

211

Operation

Driving instructions

Passenger compartment

Driving abroad

Abroad, there is an extensive  
Mercedes-Benz service network at your 
disposal. If you plan to drive into areas 
which are not listed in the index of your 
Mercedes-Benz Light Truck Center directo-
ry, you should request pertinent informa-
tion from your authorized Mercedes-Benz 
Light Truck Center.

Control and operation of radio trans-
mitters

MCS, radio and telephone*

Warning!

G

Always fasten items being carried as secure-
ly as possible.

In an accident, during hard braking or sud-
den maneuvers, loose items will be thrown 
around inside the vehicle, and cause injury 
to vehicle occupants unless the items are 
securely fastened in the vehicle.

The rear cargo compartment is the preferred 
place to carry objects. Always use the parti-
tion net when transporting cargo. Partition 
net cannot secure hard or heavy objects. Al-
ways fasten items being carried as securely 
as possible using the cargo tie-down rings in 
the cargo floor area and fastening materials.

Warning!

G

Do not forget that your primary responsibili-
ty is to drive the vehicle. Only operate the 
MCS, radio or telephone

1

 if road, weather 

and traffic conditions permit.

Bear in mind that at a speed of just 30 mph 
(approximately 50 km/h), your vehicle is 
covering a distance of approximately 
44 feet (approximately 13.5 m) every 
second.

1

Observe all legal requirements.

212

Operation

Driving instructions

Telephones and two-way radios

Radio transmitters, such as a portable tele-
phone or a citizens band unit should only 
be used inside the vehicle if they are con-
nected to an antenna that is installed on 
the outside of the vehicle.

Refer to the radio transmitter operation in-
structions regarding use of an external an-
tenna.

Catalytic converter

Your Mercedes-Benz is equipped with 
monolithic-type catalytic converters, an 
important element in conjunction with the 
oxygen sensors to achieve substantial con-
trol of the pollutants in the exhaust emis-
sions. Keep your vehicle in proper 
operating condition by following our rec-
ommended maintenance instructions as 
outlined in your Service Booklet.

Emission control

Certain engine systems serve to keep the 
toxic components of the exhaust gases 
within permissible legal limits.

These systems, of course, will function 
properly only when maintained strictly ac-
cording to factory specifications. Any ad-
justments on the engine should, therefore, 
be carried out only by qualified 
Mercedes-Benz Light Truck Center autho-
rized technicians. Engine adjustments 
should not be altered in any way. More-
over, the specified service jobs must be 

Warning!

G

Never operate radio transmitters equipped 
with a built-in or attached antenna (i.e. with-
out being connected to an external antenna) 
from inside the vehicle while the engine is 
running. Doing so could lead to a malfunc-
tion of the vehicle’s electronic system, pos-
sibly resulting in an accident and/or 
personal injury.

!

To prevent damage to the catalytic con-
verters, use only premium unleaded 
gasoline in this vehicle.

Any noticeable irregularities in engine 
operation should be repaired promptly. 
Otherwise, excessive unburned fuel 
may reach the catalytic converter, 
causing it to overheat and start a fire.

Warning!

G

As with any vehicle, do not idle, park or op-
erate this vehicle in areas where combusti-
ble materials such as grass, hay or leaves 
can come into contact with the hot exhaust 
system, as these materials could be ignited 
and cause a vehicle fire.

213

Operation

Driving instructions

carried out regularly according to 
Mercedes-Benz servicing requirements. 
For details refer to the Service Booklet.

Coolant temperature

During severe operating conditions and 
stop-and-go city traffic, the coolant tem-
perature may rise to approx. 248°F 
(120°C).

The engine should not be operated with 
the coolant temperature in the red zone. 
Doing so may cause serious engine dam-
age which is not covered by the 
Mercedes-Benz Limited Warranty.

Warning!

G

Inhalation of exhaust gas is hazardous to 
your health. All exhaust gas contains carbon 
monoxide, and inhaling it can cause uncon-
sciousness and lead to death.

Do not run the engine in confined areas 
(such as a garage) which are not properly 
ventilated. If you think that exhaust gas 
fumes are entering the vehicle while driving, 
have the cause determined and corrected 
immediately. If you must drive under these 
conditions, drive only with at least one win-
dow fully open at all times.

Warning!

G

Driving when your engine is badly over-
heated can cause some fluids which 
may have leaked into the engine com-
partment to catch fire. You could be se-
riously burned.

Steam from an overheated engine can 
cause serious burns and can occur just 
by opening the engine hood. Stay away 
from the engine if you see or hear steam 
coming from it.

Turn off the engine, get out of the vehicle 
and do not stand near the vehicle until the 
engine has cooled down.

214

Operation

At the gas station

At the gas station

Refueling

The fuel filler flap is located on the 
left-hand side of the vehicle towards the 
rear. Locking /unlocking the vehicle with 
the remote control automatically 
locks/unlocks the fuel filler flap.

1 Fuel filler flap
2 Fuel cap

Remove the key from the steering lock.

Open the fuel filler flap 1 by pulling in 
direction of the arrow.

Turn the fuel cap 2 to the left and hold 
on to it until possible pressure is re-
leased.

Take off the cap.

Only fill your tank until the filler nozzle 
unit cuts out – do not top up or overfill. 

Warning!

G

Gasoline is highly flammable and poisonous. 
It burns violently and can cause serious inju-
ry. Whenever you are around gasoline, avoid 
inhaling fumes and skin contact, extinguish 
all smoking materials. Never allow sparks, 
flame or smoking materials near gasoline!

!

The fuel filler cap is tethered to the fuel 
filler neck. Do not drop the cap. It could 
damage the vehicle paint finish.

!

To prevent damaging the lens of the 
plastic tail lamp, make certain that no 
gasoline comes into contact with it.

Warning!

G

Overfilling of the fuel tank may create pres-
sure in the system which could cause a gas 
discharge. This could cause the gas to spray 
back out when removing the fuel pump noz-
zle, which could cause personal injury.

 

 

 

 

 

 

 

Content   ..  94  95  96  97   ..