Snowmobile Ski Doo REV SERIES (2006 year). Instruction - part 61

 

  Index      Snowmobiles / ATV     Snowmobile Ski Doo REV SERIES - instruction 2006 year

 

Search            copyright infringement  

 

 

 

 

 

 

 

 

 

Content   ..  59  60  61  62   ..

 

 

Snowmobile Ski Doo REV SERIES (2006 year). Instruction - part 61

 

 

Section 06 ENGINE MANAGEMENT (SDI)

Subsection 01 (OVERVIEW)

DIAGNOSTIC MODE

The malfunctions are recorded in the memory
of the ECM. The memory of the ECM can be
checked using the VCK (Vehicle Communication
Kit) (P/N 529 035 981) to see the fault codes. Re-
fer to the DIAGNOSTIC PROCEDURES section.

ROTAX ELECTRONIC REVERSE
(RER)

There is 3 main components used for the RER
system : the start/RER switch, the ECM and the
crankshaft position sensor.

The ECM receives signals from the crankshaft po-
sition sensor (CPS) for the following functions:

– Forward engine rotation.
– Reverse engine rotation.
– Crankshaft position and engine RPM.

The ECM recognizes a signal sent by the
START/RER switch.

When switch is activated and engine is not run-
ning, ECM allows normal engine starting.

When switch is activated and engine is running,
ECM cuts off ignition. Therefore, engine RPM
gradually drops.

When engine reaches a low

threshold RPM, ECM sends an ignition spark at
a great advance creating a thrust which reverses
engine rotation.

Under a threshold low RPM or above drive pulley
engagement speed, the RER function is disabled.
Nothing takes place when pressing Start/RER but-
ton.

mmr2005-079

239

Section 06 ENGINE MANAGEMENT (SDI)

Subsection 02 (DIAGNOSTIC PROCEDURES)

DIAGNOSTIC PROCEDURES

SERVICE TOOLS

Description

Part Number

Page

GRAY diagnostic key ............................................................ 529 035 896 ......................................... 246
supply harness...................................................................... 529 035 869 ......................................... 245
VCK (Vehicle Communication Kit) ......................................... 529 035 981 ......................................... 245

GENERAL

Here is the basic order suggested to diagnose a suspected engine management or fuel injection related
problem:

– Check the chart in TROUBLESHOOTING section to have an overview of problems and suggested so-

lutions.

– Check if the engine management system (EMS) pilot lamp lights up. If so, use the VCK (Vehicle Com-

munication Kit) and look for fault codes to diagnose the trouble.

– Check all fuses, relay(s), battery and capacitor (on so equipped models).
– Check fuel pressure.
– Check spark plugs condition.
– Check all connections of the wiring harness.

Refer to COMPONENT INSPECTION, REPLACEMENT AND ADJUSTMENT section for procedures.

TROUBLESHOOTING

The following chart is provided to help in diagnosing the probable source of simple troubles.

Monitoring Beeper Coded Signals

CODED SIGNALS

POSSIBLE CAUSE

REMEDY

2 short beeps (when engine is started).

DESS/RER pilot lamp also blinks.

Confirms that proper

tether cord cap is installed.

Engine can rev above clutch engagement.

No problem detected. Good ride.

1 short beep every 1.5 seconds (when engine

is started). DESS/RER pilot lamp also blinks.

Engine cannot reach pulley engagement

speed. Vehicle cannot be driven.

Bad DESS system connection.

Defective tether cord cap.

Dirt or snow in tether cord cap.

Defective DESS post.

Reinstall tether cord cap correctly over post.

Use another programmed tether cord cap.

Clean tether cord cap.

Replace DESS post.

1 long beep per second.

Reverse is selected.

Vehicle can be driven in reverse.

3 short beeps per second. DESS/RER

pilot lamp also blinks. Engine cannot

reach pulley engagement speed. Vehicle

cannot be driven.

Wrong tether cord cap is installed.

Install proper tether cord cap.

Program key into ECM.

3 short beeps per second. Engine

overheating pilot lamp also blinks.

Engine is overheating.

Stop engine immediately and allow to

cool. Check cooling system.

mmr2005-080

241

Section 06 ENGINE MANAGEMENT (SDI)
Subsection 02 (DIAGNOSTIC PROCEDURES)

CODED SIGNALS

POSSIBLE CAUSE

REMEDY

1 long beep (2 seconds) every 15 minutes.

Low battery voltage.

Check battery and charging system.

4 short beeps every 2 minutes. Oil

pilot lamp also lights up.

Low oil level on 2-TEC models.

Check oil level and replenish as soon

as possible.

Many other codes use the engine pilot lamp and the beeper to indicate a problem. Refer to B.U.D.S. for
possible causes and service actions.

P CODE

EMS PILOT LAMP

BEEPER

DESCRIPTION

P0106

OFF

OFF

Air pressure sensor voltage out of range.

P0337

OFF

OFF

No crankshaft signal detected.

P0336

OFF

OFF

High engine RPM detected.

P0339

OFF

OFF

Crankshaft signal fault.

P0654

OFF

OFF

Tachometer RPM signal shorted to battery.

P0654

OFF

OFF

Tachometer RPM signal open circuit or shorted
to ground.

P0617

OFF

OFF

Starter relay shorted to battery.

P0616

OFF

OFF

Starter relay open circuit or shorted to ground.

P1670

OFF

OFF

Beeper shorted to battery.

P1671

OFF

OFF

Beeper open circuit or shorted to ground.

P0650

OFF

OFF

EMS pilot lamp shorted to battery.

P0650

OFF

OFF

EMS pilot lamp open circuit or shorted to
ground.

P1675

OFF

OFF

Relay 2 shorted to battery.

P1676

OFF

OFF

Relay 2 open circuit or shorted to ground.

P1148

OFF

OFF

Safety fuel cut off detected.

P1611

OFF

OFF

P+ Test of ISC output signal failed.

P0513

OFF

OFF

Incorrect DESS

®

key.

P0601

OFF

OFF

Faulty module (software of hardware damaged).

P1677

OFF

OFF

Relay 3 shorted to battery.

P1678

OFF

OFF

Relay 3 open circuit or shorted to ground.

P1648

OFF

OFF

Battery lamp shorted to battery.

P1649

OFF

OFF

Battery lamp open circuit or shorted to ground.

P0655

OFF

OFF

Engine temperature lamp shorted to battery.

P0655

OFF

OFF

Engine temperature lamp open circuit or shorted
to ground.

P1646

OFF

OFF

Engine temperature lamp shorted to battery.

242

mmr2005-080

Section 06 ENGINE MANAGEMENT (SDI)

Subsection 02 (DIAGNOSTIC PROCEDURES)

P CODE

EMS PILOT LAMP

BEEPER

DESCRIPTION

P1647

OFF

OFF

Engine temperature lamp open circuit or shorted
to ground.

P0648

OFF

OFF

DESS lamp shorted to battery.

P0648

OFF

OFF

DESS lamp open circuit or shorted to ground.

P1654

OFF

OFF

Oil lamp shorted to battery.

P1658

OFF

OFF

Oil lamp open circuit or shorted to ground.

P0117

BLINK

OFF

Engine temperature sensor voltage too low.

P0118

BLINK

OFF

Engine temperature sensor voltage too high.

P0116

BLINK

OFF

Engine temperature sensor functional problem.

P0112

BLINK

OFF

Air temperature sensor voltage too low.

P0113

BLINK

OFF

Air temperature sensor voltage too high.

P0111

BLINK

OFF

Air temperature sensor functional problem.

P0427

BLINK

OFF

Exhaust temperature sensor voltage too low.

P0428

BLINK

OFF

Exhaust temperature sensor voltage too high.

P0426

BLINK

OFF

Exhaust temperature sensor functional problem.

P0107

BLINK

OFF

Air pressure sensor voltage too low.

P0108

BLINK

OFF

Air pressure sensor voltage too high.

P0608

BLINK

OFF

Sensor's power supply voltage too low.

P0608

BLINK

OFF

Sensor's power supply voltage too high.

P0232

BLINK

OFF

Fuel pump shorted to battery.

P0231

BLINK

OFF

Fuel pump open circuit or shorted to ground.

P0080

BLINK

OFF

RAVE

®

solenoid shorted to battery.

P0079

BLINK

OFF

RAVE

®

solenoid open circuit or shorted to

ground.

P0326

BLINK

OFF

Knock sensor signal below minimum noise.

P1502

BLINK

OFF

TOPS functional problem.

P0351

BLINK

OFF

No ignition output cylinder # 1
(MAG for 2 cyl. engine).

P0352

BLINK

OFF

No ignition output cylinder # 2
(PTO for 2 cyl. engine).

P0262

BLINK

OFF

Injector cyl. # 1 OR outer MAG injector
(2 cyl.), shorted to battery.

P0261

BLINK

OFF

Injector cyl. # 1 OR outer MAG injector
(2 cyl.), open circuit or shorted to ground.

P0265

BLINK

OFF

Injector cyl. # 2 OR outer PTO injector
(2 cyl.), shorted to battery.

mmr2005-080

243

 

 

 

 

 

 

 

Content   ..  59  60  61  62   ..