Mercedes-Benz ML320. Service manual - part 118

 

  Index      Mercedes     Mercedes-Benz ML320 - service and repair manual 1997-2005 year

 

Search            copyright infringement  

 

 

 

 

 

 

 



 

 

Content   ..  116  117  118  119   ..

 

 

Mercedes-Benz ML320. Service manual - part 118

 

 

299

Technical data

Weights

Weights

Roof load max.

220 lbs (100 kg)

300

Technical data

Fuels, coolants, lubricants etc.

Fuels, coolants, lubricants etc.

Capacities

Vehicle components and their respective 
lubricants must match.

Therefore use only brands tested and 
approved by Mercedes-Benz.

Please refer to the Factory Approved 
Service Products pamphlet, or inquire at 
your Mercedes-Benz Light Truck Center.

Model

Capacity

Fuels, coolants, lubricants etc.

Engine with oil filter

ML 350, ML 500

8.5 US qt (8.0 l)

Approved engine oils

Automatic transmis-
sion

9.0 US qt (8.5 l)

MB Automatic Transmission Oil

Transfer case

1.6 US qt (1.5 l)

(Dexron 3 or Dexron 2E)

Rear axle

1.3 US qt (1.25 l)

(Hypoid gear oil SAE 90, 85 W 90)

Front axle

1.2 US qt (1.1 l)

(Hypoid gear oil SAE 90)

Power steering

approx. 0.65 US qt (0.6 l)

MB Power Steering Fluid

Front wheel hubs

approx.  1.5 oz  (43 g)  each

High temperature roller bearing grease

301

Technical data

Fuels, coolants, lubricants etc.

Model

Capacity

Fuels, coolants, lubricants etc.

Cooling system

approx. 12.7 US qt (12.0 l)

MB Anticorrosion/Antifreeze

Fuel tank

ML 350, ML 500

22.0 US gal (83.0 l)

Premium unleaded gasoline:
Posted Octane 91 (Avg. of 96 RON/86 MON

including a reserve of

approx. 3.2 US gal (12.0 l)

Air conditioning system

R-134a refrigerant and special PAG lubricant 
oil (never R-12)

Windshield washer and 
headlamp cleaning 
system
*

8.0 US qt (7.6 l)

MB Windshield Washer Concentrate

1

1

Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing or MB Windshield Washer Concentrate “S” and commercially available pre-
mixed windshield washer solvent/ antifreeze for temperatures below freezing. Follow suggested mixing ratios (

컄 page 307).

302

Technical data

Fuels, coolants, lubricants etc.

Engine oils

Engine oils are specifically tested for their 
suitability in our engines. Therefore, use 
only engine oils approved by 
Mercedes-Benz. Information on approved 
engine oils is available in the Factory 
Approved Service Products pamphlet, or at 
your authorized Mercedes-Benz Light 
Truck Center.

Engine oil additives

Do not blend oil additives with engine oil. 
They may damage the engine.

Damage or malfunctions resulting from 
blending oil additives are not covered by 
the Mercedes-Benz Limited Warranty.

Air conditioning refrigerant

R-134a (HFC) refrigerant and special PAG 
lubricating oil is used in the air condition-
ing system.

Never use R-12 (CFC) or mineral-based lu-
bricating oil. Otherwise damage to the 
system will occur.

Brake fluid

During vehicle operation, the boiling point 
of the brake fluid is continuously reduced 
through the absorption of moisture from 
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture 
content can lead to the formation of bub-
bles in the system, thus reducing the sys-
tem’s efficiency.

Therefore, the brake fluid must be re-
placed every two years, preferably in the 
spring.

Only brake fluid approved by 
Mercedes-Benz is recommended. Your au-
thorized Mercedes-Benz Light Truck 
Center will provide you with additional in-
formation.

!

Always check the oil filler cap 
(

page 221) for important information 

pertaining to the engine oil needing to 
meet a specific Mercedes-Benz specifi-
cation (e.g. MB 229.5). If such informa-
tion is printed on the oil filler cap, only 
use an engine oil from the list of ap-
proved engine oils in the Factory Ap-
proved Service Products pamphlet that 
meets the specification indicated on 
the oil filler cap.

Using engine oils of other specification 
may cause the FSS to incorrectly deter-
mine the next service interval and will 
result in engine damage not covered by 
the Mercedes-Benz Limited Warranty.

 

 

 

 

 

 

 

Content   ..  116  117  118  119   ..