Daewoo Nubira. Service manual - part 81

HORNS  9C – 3

DAEWOO V–121 BL4

MAINTENANCE AND REPAIR

ON–VEHICLE SERVICE

HORNS

(Left Horn Shown, Right Horn Similar,
If Equipped)

Removal Procedure

1.  Disconnect the negative battery cable.
2.  Disconnect the electrical connector.
3.  Remove the bolt and the horn.

Installation Procedure

Notice : Dissimilar metals in direct contact with each other
may corrode rapidly. Make sure to use the correct fasten-
ers to prevent premature corrosion.

1.  Install the horn with the bolt.

Tighten

Tighten the horn bolt to 22 N

S

m (16 lb–ft)

9C – 4

I

HORNS

DAEWOO V–121 BL4

2.  Connect the electrical connector.
3.  Connect the negative battery cable.

HORNS  9C – 5

DAEWOO V–121 BL4

GENERAL DESCRIPTION

AND SYSTEM OPERATION

HORNS

The horns are located under the hood. They are attached
near the radiator at the front of the vehicle. The horns are
actuated by pressing the steering wheel pad, which
grounds the horns

’

 electrical circuit.

SECTION : 9B

LIGHTING SYSTEMS

CAUTION : Disconnect the negative battery cable before removing or installing any electrical unit or when a tool
or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable will help
prevent personal injury and damage to the vehicle. The ignition must also be in LOCK unless otherwise noted.

TABLE OF CONTENTS

SPECIFICATIONS

9B–2

. . . . . . . . . . . . . . . . . . . . . . . . . . 

BULB USAGE CHART

9B–2

. . . . . . . . . . . . . . . . . . . . . 

FASTENER TIGHTENING SPECIFICATIONS

9B–2

. 

SCHEMATIC AND ROUTING DIAGRAMS

9B–3

. . . . . 

HEADLAMPS–ON REMINDER CHIME CIRCUIT 9B–

3

PARKING, TAIL, POSITION AND LICENSE LAMPS

CIRCUIT

9B–4

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

TURN AND HAZARD LAMPS CIRCUIT 

9B–5

. . . . . . 

BRAKE AND BACKUP LAMPS CIRCUIT

9B–6

. . . . . 

INTERIOR COURTESY LAMP AND LUGGAGE

COMPARTMENT LAMP CIRCUIT 

9B–7

. . . . . . . . . 

HEADLAMPS CIRCUIT 

9B–8

. . . . . . . . . . . . . . . . . . . . 

DAYTIME RUNNING LAMPS CIRCUIT

9B–9

. . . . . . . 

FOG LAMPS CIRCUIT

9B–10

. . . . . . . . . . . . . . . . . . . . 

DIAGNOSIS

9B–11

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

HEADLAMPS–ON REMINDER CHIME

9B–11

. . . . . . 

HEADLAMPS

9B–12

. . . . . . . . . . . . . . . . . . . . . . . . . . . . 

FOG LAMPS

9B–18

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

REAR COMBINATION LAMPS

9B–19

. . . . . . . . . . . . . 

INTERIOR COURTESY AND LUGGAGE

COMPARTMENT LAMPS

9B–28

. . . . . . . . . . . . . . . . 

MAINTENANCE AND REPAIR

9B–31

. . . . . . . . . . . . . . 

ON–VEHICLE SERVICE

9B–31

. . . . . . . . . . . . . . . . . . . . 

HEADLAMPS/FRONT TURN SIGNAL LAMPS 9B–31

HEADLAMP AIMING

9B–34

. . . . . . . . . . . . . . . . . . . . . . 

PARKING LAMPS

9B–35

. . . . . . . . . . . . . . . . . . . . . . . . 

SIDE MARKER LAMPS

9B–36

. . . . . . . . . . . . . . . . . . . 

FOG LAMPS

9B–37

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

REAR COMBINATION LAMPS

9B–39

. . . . . . . . . . . . . 

CENTER HIGH–MOUNTED STOPLAMP

(NOTCHBACK)

9B–40

. . . . . . . . . . . . . . . . . . . . . . . . . 

CENTER HIGH–MOUNTED STOPLAMP

(HATCHBACK)

9B–40

. . . . . . . . . . . . . . . . . . . . . . . . . 

CENTER HIGH–MOUNTED STOPLAMP (WAGON) 9

B–41

LICENSE PLATE LAMPS

9B–42

. . . . . . . . . . . . . . . . . . 

DOOR JAMB SWITCH

9B–42

. . . . . . . . . . . . . . . . . . . . 

INTERIOR COURTESY LAMP

9B–43

. . . . . . . . . . . . . 

MAP LAMP

9B–44

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

GLOVE BOX LAMP

9B–44

. . . . . . . . . . . . . . . . . . . . . . . 

ASHTRAY LAMP

9B–45

. . . . . . . . . . . . . . . . . . . . . . . . . 

LUGGAGE COMPARTMENT LAMP

9B–46

. . . . . . . . 

CARGO AREA LAMP (WAGON)

9B–46

. . . . . . . . . . . 

DAYTIME RUNNING LAMP MODULE

9B–47

. . . . . . . 

GENERAL DESCRIPTION AND SYSTEM

OPERATION

9B–48

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

HEADLAMPS–ON REMINDER

9B–48

. . . . . . . . . . . . . 

HEADLAMPS

9B–48

. . . . . . . . . . . . . . . . . . . . . . . . . . . . 

DAYTIME RUNNING LAMPS

9B–48

. . . . . . . . . . . . . . 

PARKING AND TURN SIGNAL LAMPS

9B–48

. . . . . 

SIDE MARKER LAMPS

9B–48

. . . . . . . . . . . . . . . . . . . 

FOG LAMPS

9B–48

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 

REAR COMBINATION LAMPS

9B–48

. . . . . . . . . . . . . 

LICENSE PLATE LAMP

9B–49

. . . . . . . . . . . . . . . . . . . 

INTERIOR COURTESY LAMP

9B–49

. . . . . . . . . . . . . 

GLOVE BOX LAMP

9B–49

. . . . . . . . . . . . . . . . . . . . . . . 

ASHTRAY LAMP

9B–49

. . . . . . . . . . . . . . . . . . . . . . . . . 

LUGGAGE COMPARTMENT LAMP

9B–49

. . . . . . . .